|Published (Last):||6 August 2006|
|PDF File Size:||7.62 Mb|
|ePub File Size:||7.22 Mb|
|Price:||Free* [*Free Regsitration Required]|
The complex interrelation of the sensors used to monitor engine operation and the ECU used to control both the fuel injection and ignition systems makes logical troubleshooting all that much more important.
95 Kawasaki Zxi Service Manual
Never attempt to perform any work with out the assistance of a service manual. Make sure the fuel is not stale. Check for leaks or restrictions in the Lines and Fittings of the low pressure fuel circuit, as directed in this section under Fuel Tank and Lines.
General knowledge information is not included. These Kawasaki PWC JetSki Jet Ski manuals contains an introductory description on and procedures for the inspection, service and overhaul of its main components.
The major difference in troubleshooting engine performance on EFI motors is the presence of the ECU and electronic engine controls. Make kawasaki jet ski 900 zxi service manual pdf download the engine mechanically has good compression refer to the Compression Check procedure that is a part of a regular Tune-Up. Is there power going to electrical switches and motors? Persons without such knowledge and skills should attempt with caution to service any component or engine by relying on this manual only.
Experience shows that most problems tend to be the result of a fairly simple and obvious cause, such as loose or corroded connectors, bad grounds or damaged wire insulation that causes a short.
locate a dealer
Zxl blocked low-pressure fuel filter causes hard starting, stalling, misfire or poor performance. Typically the engine malfunction worsens with increased engine speed. We say it is the last step, because it is the most in;olved repair procedures on the fuel system and should only be performed after all other possible causes of fuel system trouble have been eliminated. Were there any noises, odors or other unusual symptoms? Test all repairs after the work is done to make sure that the problem is fixed.
A defective choke may also cause problems. This filter prevents contaminants from reaching the lowpressure kawasaki jet ski 900 zxi service manual pdf download pump.
zxi service manual
Establish when the problem occurs. The complexity manua, a modern marine vessel demands that you approach any problem in a logical, organized manner. Furthermore, the low pressure fuel system that supplies fuel to the reservoir in the vapor separator tank operates in the same manner as the fuel circuit that supplies gasoline to the carburetor float bowl. Introduction These Kawasaki PWC JetSki Jet Ski manuals contains an introductory description on and procedures for the inspection, service and overhaul of its main components.
Before beginning troubleshooting on an EFI motor, make kawasaki jet ski 900 zxi service manual pdf download the basics are all true. Always check the obvious before assuming something complicated is the cause. If fuel deliverv problems are susoected, refer to the testina orocedures in Fuel Tank and maual to make sure the tank vent is working and that there are not leaks or restrictions that would prevent fuel from getting to the pump andlor carburetor s. Troubleshooting a fuel injected motor contains similarities to carbureted motors.
Many times fuel system troubles are caused by a plugged fuel filter, a defective fuel pump, or by a leak in the line from the fuel tank to the fuel pump. Refer to the Fuel Filter in the section on Maintenance and Tune- Up for more kawasaki jet ski 900 zxi service manual pdf download on checking, cleaning or replacing fuel filters. If a modification has been made since then, differences may sski between the content of these Kawasaki JetSki manuals and the actual watercraft.
Some causes can be traced to more than one component, so a careful verification of repair work is important in order to pick up additional malfunctions that may cause a problem to reappear or a different problem to arise. Performing careful, systematic checks will often turn up most causes on the first inspection, without wasting time checking components that have little or no relationship to the problem.
Would you believe, a majority of starting troubles, which are kawasaki jet ski 900 zxi service manual pdf download to the fuel system, are the result of an empty fuel tank or aged fuel. The last step fuel system troubleshooting is to adjust or rebuild and then adiust the carburetor.
EFI systems cannot operate properly unless the circuits are complete and a sufficient voltage is available from sko battery and charging systems. To do this, make some simple tests and observations, then eliminate the systems that are working properly, Check for obvious problems, such as broken wires and loose or dirty connections.
This makes careful visual inspection of components during testing essential to quick and accurate troubleshooting. Test for problems systematically to determine the cause once the problem area is isolated.
Does the problem appear only under certain conditions?